| 137 | 0 | 193 |
| 下载次数 | 被引频次 | 阅读次数 |
采用固相反应法制备了3种高熵ReVO4陶瓷，对其物相结构、微观形貌和振动特征采用X射线衍射、扫描电子显微镜和Raman光谱进行表征，并对微波介电性能进行了分析。结果表明：所有陶瓷样品均表现出空间群为I41/amd的四方锆石结构，致密的微观结构使其展现出良好的微波介电性能。采用Clausius-Mossotti公式解释了介电常数的变化，介电常数与离子极化率呈正相关；品质因数与填充因子具有相似的变化趋势；键价理论被用于反映晶格畸变的程度，并与谐振频率温度系数具有强关联性。
Abstract：Introduction Microwave dielectric ceramics are widely used in microwave frequency (i.e.,300 MHz–300 GHz) circuits as communication electronic components such as resonators,filters,and antennas.The dielectric permittivity (εr),quality factor (Q×f)and the temperature coefficient of resonant frequency (τf) are the main performance index to measure the quality of microwave dielectric ceramics.However,there is a constraint relationship between the performance parameters.In general,the giant εr may cause a large dielectric loss and a low Q×f,and the volatility of εr originates an enormousτf value.Therefore,materials with superior intrinsic microwave dielectric properties are rare.The existing methods of controlling microwave dielectric properties mainly include ion substitution,composite control,laminated control and non-stoichiometric ratio control.These methods often require sacrificing one parameter to satisfy other parameters.High-entropy strategy is a novel regulation method used in inorganic materials.High-entropy ceramics refer to a ceramic system with a configuration entropy (Sc) of 1.5R.The high-entropy effect,sluggish diffusion effect,lattice distortion effect and synergy in components (i.e.,cocktail effect) are four special effects of high-entropy ceramics.The high-entropy strategy shows a great potential in dielectric ceramics due to these unique effects.In this paper,high-entropy strategy was used to design rare-earth vanadate ceramics.The impact of high-entropy structure on the microwave dielectric properties was investigated.Methods High-entropy ceramics of Re VO4 were synthesized by a solid-phase method with high-purity rare earth oxides (Re_2O_3with a purity of>99.9%) and V_2O5.The ceramics with different chemical formulas (La0.2Ce0.2Nd0.2Sm0.2Eu0.2)VO4,(La0.2Ce0.2Nd0.2Sm0.2 Gd0.2)VO4,and (La0.2Ce0.2Nd0.2Sm0.2Y0.2)VO4,were denoted as Eu-5RVO,Gd-5RVO,and Y-5RVO,respectively.The raw materials were weighed according to a stoichiometric ratio and mixed in a ball mill at a rotational speed of 300r/min for 6 h.The slurry after milling was dried in an oven at 120℃for 24 h.After grinding,the powders were pre-fired in a Muffle furnace at 800℃for 6 h.Then the prepared powders were further ground for 6 h,dried,and added with a polyvinyl alcohol solution(PVA,5%) as a binder.The granulated powders were sieved by a 80/120 mesh screen and then pressed into cylindrical bulks with a thickness of 5.5–6.5 mm and diameter of 10 mm at 10 MPa.The samples were heated at 550℃for 6 h to eliminate the binder and sintered at 1 400–1 500℃for 6 h with an increment of 20℃to obtain the dense ceramics.The crystal structure of the ceramics was analyzed by X-ray diffraction (XRD,PANalytical Co.,the Netherlands).The apparent density was determined by Archimedes'drainage method.The microstructure was evaluated by a model S-4800 scanning electron microscope (SEM,Hitachi High-Technologies Co.,Japan).The dielectric properties at different microwave frequencies (i.e.,1–20GHz) were measured by a model Keysight E5071C vector network analyzer (Keysight Technologies Co.,USA) in TE011 mode based on the Hakki-Coleman method.The temperature coefficient of resonant frequency (τf) was calculated via recording the frequency drifting at 25–85℃(i.e.,f25 and f85).Results and discussion The high-entropy ceramics Eu-5RVO,Gd-5RVO,and Y-5RVO exhibit a tetragonal zircon structure with a space group I41/amd.The SEM images of the fractured cross-section of high-entropy ceramics Re VO4 show uniform grains and clear grain boundaries,along with the spatial distribution of elements based on EDS analysis.The ceramics all exhibit a dense microstructure,as well as a promising microwave dielectric performance.The dielectric permittivity is analyzed via the Clausius-Mossotti formula,which is positively correlated to ion polarization.The quality factor is primarily determined by the packing fraction.The bond valence theory is used to reflect the degree of lattice distortion,having a strong relationship with the temperature coefficient of resonance frequency.The results show that the high-entropy strategy can effectively regulate the microwave dielectric properties.Conclusions A series of high-entropy ceramics of Re VO4 were prepared by a solid-state reaction method.All the ceramics were a tetragonal zircon structure with a space group I41/amd.The phase structure,microscopic morphology,and vibration characteristics of high-entropy ceramics Re VO4 were analyzed,and the microwave dielectric properties were analyzed by the Clausius-Mossotti formula,packing fraction,and bond valence theory.The results showed that ceramic Y-5RVO exhibited an optimal microwave dielectric properties (i.e.,εr of 10.69,Q×f of 11 704 GHz,andτf of-21.70×10–6/℃).It was indicated that the high-entropy ceramics of Re VO4 could be used as competitive microwave dielectric materials.
[1]CHEN L,DENG S Q,LIU H,et al.Giant energy-storage density with ultrahigh efficiency in lead-free relaxors via high-entropy design[J].Nat Commun,2022,13(1):3089.
[2]CHEN L,YU H F,WU J,et al.Large energy capacitive high-entropy lead-free ferroelectrics[J].Nanomicro Lett,2023,15(1):65.
[3]ROST C M,SACHET E,BORMAN T,et al.Entropy-stabilized oxides[J].Nat Commun,2015,6:8485.
[4]CHEN D Q,ZHU X W,YANG X R,et al.A review on structure-property relationships in dielectric ceramics using high-entropy compositional strategies[J].J Am Ceram Soc,2023,106(11):6602-6616.
[5]XIANG H M,XING Y,DAI F Z,et al.High-entropy ceramics:Present status,challenges,and a look forward[J].J Adv Ceram,2021,10(3):385-441.
[6]BRAUN J L,ROST C M,LIM M,et al.Charge-induced disorder controls the thermal conductivity of entropy-stabilized oxides[J].Adv Mater,2018,30(51):e1805004.
[7]OSES C,TOHER C,CURTAROLO S.High-entropy ceramics[J].Nat Rev Mater,2020,5:295-309.
[8]BéRARDAN D,FRANGER S,DRAGOE D,et al.Colossal dielectric constant in high entropy oxides[J].Phys Status Solidi RRL,2016,10(4):328-333.
[9]ZHOU S Y,PU Y P,ZHANG Q W,et al.Microstructure and dielectric properties of high entropy Ba(Zr0.2Ti0.2Sn0.2Hf0.2Me0.2)O3 perovskite oxides[J].Ceram Int,2020,46(6):7430-7437.
[10]LIU J,REN K,MA C Y,et al.Dielectric and energy storage properties of flash-sintered high-entropy (Bi0.2Na0.2K0.2Ba0.2Ca0.2)TiO3 ceramic[J].Ceram Int,2020,46(12):20576-20581.
[11]YANG B B,ZHANG Y,PAN H,et al.High-entropy enhanced capacitive energy storage[J].Nat Mater,2022,21(9):1074-1080.
[12]PENG Y F,LI J Z,XIAO E C,et al.Lattice vibrational characteristics,dielectric properties and structure-property relationships of(1-x)SrWO4-xTiO2 composite ceramics[J].Mater Chem Phys,2021,258:123889.
[13]PENG H Y,HUANG J,REN H S,et al.Parallel structure enhanced polysilylaryl-enyne/Ca0.9La0.067TiO3 composites with ultra-high dielectric constant and thermal conductivity[J].ACS Appl Mater Interfaces,2022,14(40):45893-45903.
[14]LIU K,ZHANG H W,LIU C,et al.Crystal structure and microwave dielectric properties of (Mg0.2Ni0.2Zn0.2Co0.2Mn0.2)2SiO4-A novel high-entropy ceramic[J].Ceram Int,2022,48(16):23307-23313.
[15]CHEN D Q,ZHU X W,XIONG S Y,et al.Tunable microwave dielectric properties in rare-earth niobates via a high-entropy configuration strategy to induce ferroelastic phase transition[J].ACSAppl Mater Interfaces,2023,15(45):52776-52787.
[16]XIANG H C,YAO L,CHEN J Q,et al.Microwave dielectric high-entropy ceramic Li(Gd0.2Ho0.2Er0.2Yb0.2Lu0.2)GeO4 with stable temperature coefficient for low-temperature cofired ceramic technologies[J].J Mater Sci Technol,2021,93:28-32.
[17]LIN F L,LIU B,HU C C,et al.Novel high-entropy microwave dielectric ceramics Sr(La0.2Nd0.2Sm0.2Eu0.2Gd0.2)AlO4 with excellent temperature stability and mechanical properties[J].J Eur Ceram Soc,2023,43(6):2506-2512.
[18]LIN F L,LIU B,ZHOU Q W,et al.Novel non-equimolar SrLa(Al0.25Zn0.125Mg0.125Ga0.25Ti0.25)O4 high-entropy ceramics with excellent mechanical and microwave dielectric properties[J].J Eur Ceram Soc,2023,43(15):6909-6915.
[19]XIE M J,LI X,LAI Y M,et al.Phase evolution and microware dielectric properties of high-entropy spinel-type(Mg0.2Co0.2Ni0.2Li0.4Zn0.2)Al2O4 ceramics[J].J Eur Ceram Soc,2024,44(1):284-292.
[20]OLIVEIRA R G M,DE MORAIS J E V,BATISTA G S,et al.Dielectric characterization of BiVO4-TiO2 composites and applications in microwave range[J].J Alloys Compd,2019,775:889-895.
[21]WANG Y,ZUO R Z,ZHANG C,et al.Low-temperature-fired ReVO4(Re=La,Ce) microwave dielectric ceramics[J].J Am Ceram Soc,2015,98(1):1-4.
[22]LI W,FANG L,SUN Y H,et al.Preparation,crystal structure and microwave dielectric properties of rare-earth vanadates:ReV O4(Re=Nd,Sm)[J].J Electron Mater,2017,46(4):1956-1962.
[23]VALANT M,SUVOROV D.Chemical compatibility between silver electrodes and low-firing binary-oxide compounds:Conceptual study[J].J Am Ceram Soc,2000,83(11):2721-2729.
[24]ZHOU D,LI W B,XI H H,et al.Phase composition,crystal structure,infrared reflectivity and microwave dielectric properties of temperature stable composite ceramics (scheelite and zircon-type) in BiVO4-YVO4system[J].J Mater Chem C,2015,3(11):2582-2588.
[25]ZHOU D,PANG L X,GUO J,et al.Influence of Ce substitution for Bi in BiVO4 and the impact on the phase evolution and microwave dielectric properties[J].Inorg Chem,2014,53(2):1048-1055.
[26]SHANNON R D.Revised effective ionic radii and systematic studies of interatomic distances in halides and chalcogenides[J].Acta Crystallogr Sect A,1976,32(5):751-767.
[27]GUO H H,ZHOU D,LIU W F,et al.Microwave dielectric properties of temperature-stable zircon-type(Bi,Ce)VO4 solid solution ceramics[J].J Am Ceram Soc,2020,103(1):423-431.
[28]SHANNON R D.Dielectric polarizabilities of ions in oxides and fluorides[J].J Appl Phys,1993,73(1):348-366.
[29]BRESE N E,O’KEEFFE M.Bond-valence parameters for solids[J].Acta Crystallogr Sect B,1991,47(2):192-197.
[30]KIM E S,CHUN B S,FREER R,et al.Effects of packing fraction and bond valence on microwave dielectric properties of A2+B6+O4 (A2+:Ca,Pb,Ba;B6+:Mo,W) ceramics[J].J Eur Ceram Soc,2010,30(7):1731-1736.
[31]CHEN L,CHEN Z T,LI B.DyVO4:A novel microwave dielectric ceramic with low dielectric constant[J].Phys B Condens Matter,2023,649:414462.
基本信息:
DOI：10.14062/j.issn.0454-5648.20240163
中图分类号:TQ174.1
引用信息:
[1]陈德钦,莫尘,农莲汀,等.高熵ReVO_4陶瓷与微波介电性能（英文）[J].硅酸盐学报,2024,52(09):2907-2914.DOI:10.14062/j.issn.0454-5648.20240163.
2024-09-03
2024-09-03
2024-09-03